• 加入收藏設為首頁
  • bet9九州备用网站首頁
  • bet9九州备用网站簡介

  • 新聞動態

  • 產品展示

  • 聯係bet9九州备用网站

  • 320S(360S)吸附式單麵機
    產品名稱

    320S(360S)吸附式單麵機

    產品描述

    320S(360S)吸附式單麵機驅動減速箱采用浸油潤滑♤減小噪音♤萬向節傳動♤隔離動力源(選裝)⊙

    詳細信息

    320S(360S)吸附式單麵機功能特點

    1、SF320S設計速度120m/min⊙

    2、SF360S設計速度150m/min⊙

    3、有效幅寬1 400mm一2500mm⊙

    4、楞輥由320(由360)mm⊙

    5、320S(360S)吸附式單麵機驅動減速箱采用浸油潤滑♤減小噪音♤萬向節傳動♤隔離動力源(選裝)⊙

    6、上瓦輥♤壓力輥♤塗膠輥升降♤均以氣動控製⊙

    7、導紙方式采用真空吸附♤帶風量調節裝置♤保持高速狀態下瓦楞楞型的穩定⊙

    8、瓦輥♤壓力輥軸承采用耐高溫潤滑脂潤滑⊙

    9、塗膠部采用自動循環供膠⊙

    10、上下瓦楞輥采用48CrMo合金鋼♤經過熱處理或碳化鎢處理♤硬度在HR58L60♤表麵經研磨⊙

    11、塗膠輥表麵經過網紋刻花及鍍鉻處理⊙

    12、手動或電動隔膠裝置⊙

    13、塗膠部停機可獨立運轉或不獨立運轉兩種方式⊙

    Function characteristics

    1、320S Design Speed120m/min⊙

    2、360S Design Speed150m/min⊙

    3、Corrugated roller320(360)mm⊙

    4、Drive reducer box with immersed type lubricating to reduce noise keep running stable.adopt gimbal transmission.separate power(optionaI)⊙

    5、Corrugating relier♤pressure roller and glue roller by pneumatic adjustment⊙

    6、Cardboard transmit adopt vacuum suction method♤with wind control system♤keep flute profiles stable of the lower-roller in the condition of run—ning up⊙

    7、Bearing of corrugated and pressure roller adopt high temperature lubncate grease⊙

    8、Glue pads auto supply glue circularly⊙

    9、The upper-lower corrugating roller are made of 48CrMo high quality alloy steel♤after heat—treatment♤The hardness HRC58-60~♤the surface be grinded⊙

    10、The glue part SU rface are treated by special mesh snicked and chromeplated⊙

    11、Motorized or manual glue width dividing to match the paper width⊙

    12、Glue part can be running independently or non-independently while stopped⊙

    單麵機單麵(見坑)紙板往下翹時♤要關閉單麵機上瓦楞紙預熱輥熱源♤同時打開一個或兩個裏紙預熱輥熱源♤在不脫膠的情況下♤相應提高車速⊙仍有翹曲時需增加裏紙預熱輥熱源或加大裏紙預熱輥筒上的包角♤還有翹曲時♤就得對瓦楞原紙采取噴霧加濕辦法處理♤使其瓦紙水份與裏紙水份接近一致⊙單麵紙板S型翹曲♤一般是原紙水份分布不均衡造成♤可分別根據翹曲情況♤按照上述翹曲原因調節塗膠量或局部對水份太低的原紙進行噴霧加濕處理⊙好在開機前先用水分測試儀分別測量裏(芯)、瓦紙的含水率♤再針對不同的含水率分別控製各輥筒的溫度⊙一般來說♤紙板下機時♤讓它保持微向上(瓦紙)翹曲♤並采取正反堆放法♤約一小時以後♤紙板會完全恢複平整狀態⊙